ISSN   1004-0595

CN  62-1224/O4

高级检索
唐鹏, 李杰, 涂小慧, 李卫. 两种碳含量Q-P马氏体钢冲击磨损行为研究[J]. 摩擦学学报, 2023, 43(2): 189-196. DOI: 10.16078/j.tribology.2021248
引用本文: 唐鹏, 李杰, 涂小慧, 李卫. 两种碳含量Q-P马氏体钢冲击磨损行为研究[J]. 摩擦学学报, 2023, 43(2): 189-196. DOI: 10.16078/j.tribology.2021248
TANG Peng, LI Jie, TU Xiaohui, LI Wei. Effect of Carbon Content on Wear Resistance Resistant Properties of Quenching-Partitioning Martensitic Steel[J]. TRIBOLOGY, 2023, 43(2): 189-196. DOI: 10.16078/j.tribology.2021248
Citation: TANG Peng, LI Jie, TU Xiaohui, LI Wei. Effect of Carbon Content on Wear Resistance Resistant Properties of Quenching-Partitioning Martensitic Steel[J]. TRIBOLOGY, 2023, 43(2): 189-196. DOI: 10.16078/j.tribology.2021248

两种碳含量Q-P马氏体钢冲击磨损行为研究

Effect of Carbon Content on Wear Resistance Resistant Properties of Quenching-Partitioning Martensitic Steel

  • 摘要: 高强韧、低成本淬火-分配(Q-P)马氏体钢有望成为新一代抗冲击磨料磨损材料. 碳元素是影响Q-P马氏体钢强度和韧性的重要合金元素,但其对Q-P马氏体钢抗冲击磨料磨损性能的影响仍不清楚. 本文中对比研究了碳质量分数为0.3%和0.4%两种Q-P马氏体钢的冲击磨料磨损行为. 研究表明,冲击磨料磨损过程中,磨痕亚表层形变层内发生板条组织纳米化、残余奥氏体向马氏体转变等行为,这导致疲劳裂纹形变层/基体层界面萌生. 当碳质量分数由0.3%增加至0.4%时,碳化物从Q-P马氏体钢基体中析出,这加剧疲劳裂纹的萌生及扩展,最终导致Q-P马氏体钢的抗冲击磨料磨损性能降低约7%.

     

    Abstract: Q-P martensitic steel is the latest developed third-generation structural steel. Specifically, the carbon-rich retained austenite can be formed by austenitizing the steel of medium and low carbon, high silicon and low alloy, quenching it to the temperature between the beginning of martensite transformation (MS) and the end of martensite transformation (MD), and then distributing the carbon element from martensite to austenite for a short isothermal time above the quenching temperature or MS temperature. At present, because of its excellent strength, plasticity and easy realization, it is often used in the production of automobile industry. However, its application in impact wear condition needs to be studied. With the rapid development of metallurgical and chemical industries, such as manganese steel and bainitic steel, it is increasingly difficult to meet the requirements of high impact wear resistance. Q-P steel is expected to become a new generation of wear-resistant materials due to its low cost and high performance. However, the effect of carbon content on the impact abrasive wear behavior of Q-P martensitic steel remains unclear. In order to reveal the mechanism of carbon content on the impact abrasive wear resistance of Q-P martensitic steel, this paper compared the wear loss, wear mark surface and sub surface morphology of two kinds of Q-P martensitic steel with carbon mass fraction of 0.3% and 0.4% respectively. To be specific, the impact of ore on the ball mill in reality was simulated, and gravel was used as the wear medium. After Q-P heat treatment of two kinds of independently developed cast low-alloy steels with carbon content, they were processed into a rectangle with a size of 10~30 mm3 and an arc shape at the front end. In addition, the lower test block (45 steel with hardness value of 455 HV) was impacted at the rate of 100 times/min using a drop hammer with the total impact energy of 3j and the test sample. During this period, quartz sand of 0.18~0.25 mm was used to flow through the impact surface at the rate of 50 kg/h. The sample should be weighed after ultrasonic cleaning and drying every half an hour. After the test, the wear morphology of the sample surface and the cross section of the sub surface layer were observed and tested by scanning electron microscope and projection electron microscope. Combining with the structural damage, this paper analyzed the formation mechanism of the sub standard layer of the sample. The V-notch impact test was carried out on the sample, the micro Vickers hardness value of the matrix structure and sub surface was measured, the carbide content on the matrix surface was analyzed by electron backscatter diffraction, and the residual austenite content was analyzed by X-ray. As shown by the results, the impact wear resistance decreased by about 7% with the increase of carbon content. In the process of impact wear, the material loss of Q-P martensitic steel was mainly ploughing and fatigue spalling. Due to the small difference in hardness between the two sub surfaces, the decrease of impact wear resistance was mainly attributed to the increase of fatigue cracks. In the process of impact wear, the nanostructure of lath structure and the transformation of residual austenite to martensite occurred on the sub surface layer. At the same time, the initiation of fatigue crack mainly came from the difference of microstructure and hardness between the interface structure of deformation layer and matrix layer. In conclusion, with the increase of carbon content, carbides precipitate in the matrix of Q-P martensitic steel, which intensifies the initiation and propagation of fatigue cracks in the process of impact wear, and finally triggers the reduction of impact abrasive wear resistance of the material.

     

/

返回文章
返回