ISSN   1004-0595

CN  62-1224/O4

高级检索
袁伟, 王昊天, 郭前建, 王文华, 朱帅伦, 陈书童, 吕学祜, 朱玉麒. 冲击载荷下Al2O3磨料对齿轮磨损行为的作用机理研究[J]. 摩擦学学报, 2023, 43(6): 682-691. DOI: 10.16078/j.tribology.2022046
引用本文: 袁伟, 王昊天, 郭前建, 王文华, 朱帅伦, 陈书童, 吕学祜, 朱玉麒. 冲击载荷下Al2O3磨料对齿轮磨损行为的作用机理研究[J]. 摩擦学学报, 2023, 43(6): 682-691. DOI: 10.16078/j.tribology.2022046
YUAN Wei, WANG Haotian, GUO Qianjian, WANG Wenhua, ZHU Shuailun, CHEN Shutong, LV Xuehu, ZHU Yuqi. Action Mechanism of Al2O3 Abrasive on Gear Wear Behavior under Impact Load[J]. TRIBOLOGY, 2023, 43(6): 682-691. DOI: 10.16078/j.tribology.2022046
Citation: YUAN Wei, WANG Haotian, GUO Qianjian, WANG Wenhua, ZHU Shuailun, CHEN Shutong, LV Xuehu, ZHU Yuqi. Action Mechanism of Al2O3 Abrasive on Gear Wear Behavior under Impact Load[J]. TRIBOLOGY, 2023, 43(6): 682-691. DOI: 10.16078/j.tribology.2022046

冲击载荷下Al2O3磨料对齿轮磨损行为的作用机理研究

Action Mechanism of Al2O3 Abrasive on Gear Wear Behavior under Impact Load

  • 摘要: 为了探究大型风电齿轮受冲击载荷在三体磨料磨损状态下的磨损特征与演变机理,需对初始磨粒混入的45钢斜齿轮磨损特征与运行状态进行分析研究. 试验从齿轮磨损量、齿面磨损形貌分析、油液磨粒分析和振动分析4个方面进行磨损机理研究. 利用磁粉制动器施加冲击载荷来模拟实际工况,使用颗粒计数器、单联式铁谱仪和扫描电子显微镜对油样磨粒和齿轮齿面损伤形貌进行观测. 结果表明:初始硬质颗粒加速齿轮齿面磨损,导致齿轮提前进入剧烈磨损阶段,并引起齿面发生严重损伤,产生磨粒尺寸较大;对斜齿轮施加冲击载荷的加载方式加剧了磨粒磨损并扩大了应力集中,使得表面大磨粒脱落,齿宽降低,从而导致齿轮断裂失效. 研究聚焦风电齿轮在风沙环境下易发生磨粒磨损的异常工况,研究结果将为改善风电齿轮在此类异常工况下的磨损状态,提供理论依据.

     

    Abstract: In order to explore the wear characteristics and evolution mechanism of large-scale wind power generation gears under impact load under the three body abrasive wear state, it is necessary to analyze and study the wear characteristics and working state of 45 steel helical gears mixed with initial abrasive particles. An integrated data acquisition test-bed was built, and 800 ml (0.2 mg/ml) Al2O3 three body abrasive oil was added to the test gearbox. In the experiment, 32 Caltex White Oil Pharma was used to accelerate the wear process of the test. The lubricating oil had good oxidation stability, a viscosity index of 32 and a flash point of 208 ℃. Oil bath lubrication was used in the test gearbox. This method was fully lubricated. The friction surface affected by the oil bath was covered with an oil film during the whole process of wear. The impact load (40 N·m) applied by the magnetic particle brake was used to simulate the actual working conditions. In addition, the application frequency of the impact load was set to be applied every 30 minutes and completed every two minutes. In the test, 20 ml of oil samples were taken from the test gearbox every 60 minutes. For the obtained oil sample, 5 ml was taken to prepare the spectrum, and the remaining 15 ml was detected by the YJS−170 particle counter to determine the abrasive particles in the oil size and quantity. At 147 h, the vibration and noise of the gear in the experimental group increased, the wear rate continued to rise, and finally there was an impact noise. The gear was taken out and broken. It was judged that the gear was invalid at this time. After the experiment, the tooth surface of the failed gear was sliced by wire cutting. Combined with the oil samples obtained during the experiment, the wear mechanism was studied from four aspects: gear wear, tooth surface wear morphology analysis, oil analysis and vibration analysis. The wear particles in the oil sample and the damage morphology of the gear tooth surface were observed by particle counter, single ferrograph and scanning electron microscope. The results showed that the initial hard particles accelerate the wear of the gear tooth surface, leaded to the gear entering the fatigue wear stage in advance, and caused serious damage to the tooth surface, resulting in large wear particle size. The loading method of applying impact loaded to helical gears intensifies adhesive wear, expanded stress concentration, and caused large abrasive particles on the surface to fall off, resulting in gear fracture and failure. Observe the wear of gear tooth surface. Under the repeated action of impact load, the part above the pitch line of gear tooth surface was seriously worn and deformed; Fatigue wear occurred earlier in the group with hard particles. Based on the oil wedge theory, pitting corrosion was easy to occur during the operation of the gear, resulting in plastic deformation and surface hardening, and finally large pieces of surface material fall off. The research focused on the abnormal condition of wind turbine gear, which was prone to abrasive wear in sandy environment. The research results will provide a theoretical basis for improving the wear state of wind turbine gears under this abnormal condition.

     

/

返回文章
返回