ISSN   1004-0595

CN  62-1095/O4

高级检索
三氧化二铝短纤维对ZA22合金干摩擦磨损性能的影响[J]. 摩擦学学报, 1995, 15(3): 193-198.
引用本文: 三氧化二铝短纤维对ZA22合金干摩擦磨损性能的影响[J]. 摩擦学学报, 1995, 15(3): 193-198.
Effects of Al2O3 Short Fibers on the Dry Friction-Wear Properties of ZA22 Alloy[J]. TRIBOLOGY, 1995, 15(3): 193-198.
Citation: Effects of Al2O3 Short Fibers on the Dry Friction-Wear Properties of ZA22 Alloy[J]. TRIBOLOGY, 1995, 15(3): 193-198.

三氧化二铝短纤维对ZA22合金干摩擦磨损性能的影响

Effects of Al2O3 Short Fibers on the Dry Friction-Wear Properties of ZA22 Alloy

  • 摘要: 针对无油润滑场合的实际需要,采用挤压铸造法制取了Al2O3短纤维强化ZA22合金复合材料,并对其在干摩擦条件下的摩擦磨损性能进行了试验研究,同时还用扫描电子显微镜对试样磨损表面形貌进行了观察,进而对材料的磨损机理作了分析与讨论。结果表明,随着Al2O3短纤维含量的增大,ZA22/Al2O3复合材料的耐磨性能提高,但摩擦性能降低;当纤维取向垂直于摩擦而时,复合材料的摩擦磨损性能比纤维平行于摩擦面取向

     

    Abstract: In view of the practical requirement in the field without lubricants,Al2O3 short fiberreinforced ZA22 alloy composites were prepared by means of squeeze casting method,and theirfriction-wear properties were investigated under the condition of dry friction. At the same time,themorphologies of wear surfaces were observed by means of scanning electron microscopy(SEM),andthen the wear mechanisms of those materials were analysed and discussed.The results show that thewear resistance of ZA22/Al2O3 composites is improved with the increase of Al2O3 fibers content,butthe friction property decreases.When fibers are vertical with the wear surface,the friction-wearproperties of the copmosites are better than that when fibers are parallel to the wear surface. Withthe increase of the load or wearing time,the friction coefficient of the composites decreases orincreases,and the weight loss of the composites increases obviously,but the increasing amplitude ofweight loss is smaller than that of ZA22 alloy matrix,and the increasing amplitude of the frictioncoefficient is greater than that of ZA22 alloy matrix. The wear mechanism of ZA22 alloy is mainlythe severe ploughing groove and adhesion,and that of ZA22/Al2O3 composites is mainly the slightploughing groove and oxidation.

     

/

返回文章
返回