ISSN   1004-0595

CN  62-1224/O4

高级检索

不同表面处理20CrMo与GCr15配对摩擦副的极端工况摩擦学行为研究

Tribological Behavior of Friction Pairs of 20CrMo with Different Surface Treatment and GCr15 under Extreme Conditions

  • 摘要: 传统的渗碳工艺难以保证精密减速机的齿轮摩擦副在极端工况下的寿命,需要新的表面热处理技术来提升齿轮摩擦副耐磨性. 本文中针对精密减速机的齿轮摩擦副(GCr15/3种不同表面处理的20CrMo),开展了高载荷(4 GPa)下的变速试验和高转速(562 mm/s)下的变载试验. 高载荷的变速试验结果表明:渗碳+2次淬火处理的20CrMo在低转速(50 mm/s)和额定转速(300 mm/s)下展现出最佳的耐磨性能. 高浓度碳氮共渗处理的20CrMo在高转速下的耐磨性更出色. 此外,耐磨性与摩擦反应膜中磷(P)的含量呈现正相关性. 高转速的变载试验结果表明:在额定载荷(2 GPa)下,渗碳+2次淬火的20CrMo耐磨性最好. 综合分析,在高载和高速工况下,高浓度碳氮共渗工艺能够细化表层碳氮化合物,伴随着表面高P含量的摩擦反应膜,有益于降低摩擦副表面摩擦系数并提高其耐磨性. 在其他工况下,渗碳+2次淬火工艺对20CrMo耐磨性的提升效果最佳. 本研究中为提高机器人用精密减速机的齿轮的耐磨性和使用寿命提供了重要参考.

     

    Abstract: Precision reducers are widely applied in industrial robots nowadays to meet the requirements of high accuracy, heavy load and high reliability. Severe wear damage is prone to occur in gear friction pairs of precision reducers under extreme working conditions, such as heavy load, low speed and boundary lubrication. To improve the tribological performance of the GCr15 (ball)-20CrMo (disk) friction pair in precision reducer, three different friction pairs, GCr15-20CrMo with carburizing and twice quenching (FP1), GCr15-20CrMo with nitrocarburizing (FP2) and GCr15-20CrMo with high concentration nitrocarburizing (FP3) were prepared. The high temperature (100 ℃) and heavy load (maximum Hertzian contact pressure 4 GPa) tribological experiments were conducted by the UMT-5 testing machine, followed by the high temperature and high speed(maximum sliding velocity 562 mm/s) tribological experiments. The wear resistance performance of the three heat treatment technologies was evaluated based on the micro-hardness, friction coefficient, microstructure morphology, element distribution, wear scar dimensions and wear rate of the friction pairs. The hardness results demonstrated that carburizing and twice quenching heat treatment technology could induce the highest hardness for 20CrMo. While the 20CrMo disk after nitrocarburizing exhibited the lowest hardness value in the three friction pairs. The results of heavy load tribological experiments showed that abrasive wear was the main reason for failure of the friction pairs. Under the condition of low speed (50 mm/s) and nominal speed (300 mm/s), the friction coefficient of the three friction pairs was almost not influenced by variations of the heat treatment technologies. The white light morphology results revealed that FP2 and FP3 had deeper furrows on the 20CrMo disk, leading to higher wear rate values(183.61 μm3/(N·m) and 252.04 μm3/(N·m) at low speed, 19.21 μm3/(N·m) and 33.93 μm3/(N·m) at nominal speed). The wear rate of FP1 was relatively 94.47 μm3/(N·m) and 10.46 μm3/(N·m) at low speed and nominal speed. In addition, the EDS analysis on the worn area of the three friction pairs indicated that tribo-film was generated on the worn area attributed to the presence of P element. Notably, the P element content on the worn area of FP1 (0.62%) was higher than that of FP2 (0.35%) and FP3 (0.39) at the relatively lower speed. It could be concluded that the wear resistance of 20CrMo steel had been improved using carburizing and twice quenching technology. In case of the heavy-load and high-speed condition, the P element content on the worn area of FP3 reached 0.53%, which was the highest in the three friction pairs. The wear rate of 20CrMo disk for FP1, FP2 and FP3 were relatively 79.11 μm3/(N·m), 42.33 μm3/(N·m) and 34.45 μm3/(N·m). High concentration nitrocarburizing technology was beneficial for enhancing the tribological performance of 20CrMo steel. These findings further demonstrates that the wear resistance performance of the 20CrMo steel was better with higher P element content in the tribo-film. The results of high speed indicated that there were no furrows observed on the wear scar of the three friction pairs under nominal load condition comparing with that under heavy load condition. FP1 presented the best wear resistance with the wear rate value of 9.22 μm3/(N·m), lower than the wear rate of FP2 23.40 μm3/(N·m) and FP3 23.56 μm3/(N·m). This was due to the highest surface hardness of 20CrMo disk processed by carburizing and twice quenching. This study provided a significant theoretical reference for the improving of tribological performance and longevity of life for the gear friction pairs in precision reducers.

     

/

返回文章
返回