ISSN   1004-0595

CN  62-1224/O4

高级检索
周鑫鑫, 逄显娟, 岳世伟, 张玉言, 张浩, 于波. 表面织构与离子液体润滑组合体系的摩擦学性能研究[J]. 摩擦学学报, 2021, 41(6): 995-1003. DOI: 10.16078/j.tribology.2021109
引用本文: 周鑫鑫, 逄显娟, 岳世伟, 张玉言, 张浩, 于波. 表面织构与离子液体润滑组合体系的摩擦学性能研究[J]. 摩擦学学报, 2021, 41(6): 995-1003. DOI: 10.16078/j.tribology.2021109
ZHOU Xinxin, PANG Xianjuan, YUE Shiwei, ZHANG Yuyan, ZHANG Hao, YU Bo. Tribological Properties of Combination of Surface Texture and Ionic Liquids[J]. TRIBOLOGY, 2021, 41(6): 995-1003. DOI: 10.16078/j.tribology.2021109
Citation: ZHOU Xinxin, PANG Xianjuan, YUE Shiwei, ZHANG Yuyan, ZHANG Hao, YU Bo. Tribological Properties of Combination of Surface Texture and Ionic Liquids[J]. TRIBOLOGY, 2021, 41(6): 995-1003. DOI: 10.16078/j.tribology.2021109

表面织构与离子液体润滑组合体系的摩擦学性能研究

Tribological Properties of Combination of Surface Texture and Ionic Liquids

  • 摘要: 利用激光加工技术在钛合金表面构建不同尺寸的圆形微坑织构图案. 利用MS-T3001型试验机测试了圆形微坑织构、离子液体1-丁基-3-甲基咪唑三氟甲基磺酰胺盐和十四烷基三丁基季鏻双(2-乙基己基)磷酸盐及二者构成润滑组合的摩擦磨损性能. 利用金相显微镜观察圆形微坑织构的尺寸和表面形貌,利用扫描电镜分析摩擦过程前后织构化表面的形貌,采用ANSYS Fluent软件模拟分析表面织构参数和离子液体理化性质对摩擦学性能的影响. 结果表明,表面织构、离子液体、表面织构与离子液体的复合体系均展示了良好的减摩抗磨性能. 优化表面织构与离子液体的组合能够提升润滑体系的摩擦学性能. 表面织构与离子液体组成的复合润滑体系,摩擦系数随圆形微坑织构直径的增大而减小,归因于圆形微坑织构能够储存磨屑和离子液体并形成稳定的离子液体润滑薄膜,黏度较大的离子液体在收敛区间产生楔形效应,导致对上摩擦副升力增大.

     

    Abstract: Titanium alloys have been widely used in engineering fields due to their high corrosion resistance, good toughness and specific strength and many other excellent properties. However, titanium alloys are especially sensitive to adhesive wear with poor wear resistance under higher loads. In past several decades, many researchers have found that the textured surface can improve tribological performance, which is suitable for severe working environments. The influence of surface texture on the tribological properties mainly depends on various factors such as texture shape, depth and size parameters and processing accuracy. In past twenty years, ionic liquids have been extensively and intensively studied as lubricant oils and lubricant additives. In our work, laser processing technology was used to construct circular dimple texture patterns with different diameters on titanium alloy (Ti-6Al-4V) surface. Two kinds of ionic liquids (1-butyl-3-methylimidazolium Bis(trifluoromethanesulfonyl)-imide and Tributyltetradecyl phosphonium Bis(2-ethylhexyl)-phosphate) were synthesized and characterized. MS-T3001 tribometer was used to test friction coefficients of Ti-6Al-4V surfaces under different conditions, which included surfaces with and without circular dimple texture, with and without ionic liquids, and the lubricant combination of textured surfaces and ionic liquids. Before friction process, the texture of circular pits was observed on a metallurgical microscope. A scanning electron microscope was used to analyze the morphology of the textured surface before and after rubbing. ANSYS Fluent software was used to simulate and analyze the influence mechanism of surface texture parameters and ionic liquid’s viscosity on tribological performance. In experimental process, both textured surface and ionic liquid exhibited good friction-reduction behavior. Wear scar analysis were also consistent with the decreasing trend of friction coefficient. Lower friction coefficients from textured surfaces could be attributed to dimple’s collecting and storing worn debris. Tribological performances of ionic liquids were excellent due to their special physical and chemical properties. In the lubricant combination system, size parameters of textured surface and species of ionic liquid were chosen to optimize tribological properties. Under the combination conditions, it was found that friction coefficients decreased with the increase of diameters of the circular dimple texture and the ionic liquid with higher viscosity also provided better friction-reduction behavior. Two-dimensional simplified simulation of friction process was carried out in ANSYS Fluent to simulate the lifting force in the lubricant combination. As the lubricant fluid, ionic liquid produced a wedge effect in the convergence interval, which generated a lifting force on the upper friction pair. The simulation results showed that in the lubricant combination, the friction coefficients decreased with the increase of diameter of the circular dimple on textured surfaces, simultaneously ionic liquid with higher viscosity producing a higher lifting force on the upper friction pair. The simulated results about the lubricant combination of surface texture and ionic liquids were consistent with the experimental results, which confirmed to optimize the tribological performance by tuning the size of texture surface and choosing the species of ionic liquids.

     

/

返回文章
返回