ISSN   1004-0595

CN  62-1224/O4

高级检索
魏徐兵, 冯海燕, 尹萍妹, 陈赞, 丁佳晴, 卢诗琪, 杜乃洲, 李晓伟, 张广安. N掺杂对Si-DLC薄膜的结构性能影响及摩擦机理研究[J]. 摩擦学学报(中英文), 2024, 44(9): 1−17. doi: 10.16078/j.tribology.2023154
引用本文: 魏徐兵, 冯海燕, 尹萍妹, 陈赞, 丁佳晴, 卢诗琪, 杜乃洲, 李晓伟, 张广安. N掺杂对Si-DLC薄膜的结构性能影响及摩擦机理研究[J]. 摩擦学学报(中英文), 2024, 44(9): 1−17. doi: 10.16078/j.tribology.2023154
WEI Xubing, FENG Haiyan, YIN Pingmei, CHEN Zan, DING Jiaqing, LU Shiqi, DU Naizhou, LI Xiaowei, ZHANG Guangan. Understanding the Role of N-Incorporation on the Structure and Properties of Si-DLC Film and the Tribological Mechanism[J]. Tribology, 2024, 44(9): 1−17. doi: 10.16078/j.tribology.2023154
Citation: WEI Xubing, FENG Haiyan, YIN Pingmei, CHEN Zan, DING Jiaqing, LU Shiqi, DU Naizhou, LI Xiaowei, ZHANG Guangan. Understanding the Role of N-Incorporation on the Structure and Properties of Si-DLC Film and the Tribological Mechanism[J]. Tribology, 2024, 44(9): 1−17. doi: 10.16078/j.tribology.2023154

N掺杂对Si-DLC薄膜的结构性能影响及摩擦机理研究

Understanding the Role of N-Incorporation on the Structure and Properties of Si-DLC Film and the Tribological Mechanism

  • 摘要: 采用平板阴极等离子体增强化学气相沉积技术,通过调控N2流量在GCr15基底上制备了系列硅氮共掺杂类金刚石碳基(Si/N-DLC)薄膜,分析探索N掺杂对于Si-DLC薄膜结构、力学性能和摩擦学行为的作用规律以及Si/N-DLC薄膜的低摩擦磨损机理. 结果表明:N元素的引入促进Si-DLC薄膜中sp2-C结构的形成,降低了薄膜的硬度和弹性模量,但能大幅改善Si-DLC薄膜的韧性并增强结合(>20 N). 更重要的是N掺杂可有效降低Si-DLC薄膜的摩擦系数并改善其耐磨性能,摩擦系数和磨损率相较于Si-DLC薄膜分别降低了约26%和45%. 其摩擦机理是类石墨碳(GLC)转移膜的形成使得摩擦界面发生转移,有效降低了Si/N-DLC薄膜的摩擦系数,并且依赖于摩擦界面的石墨化程度和氢含量. 而磨损行为取决于其薄膜自身韧性和抵抗弹塑性变形的能力,磨痕内部脆性断裂缺口会造成转移膜的大面积破坏,加剧了黏着磨损. 此外,确定了Si/N-DLC薄膜低摩擦(摩擦系数≤0.05)的最佳服役区间,相关结果为Si/N-DLC薄膜的结构性能调控和工程应用提供参考.

     

    Abstract: Si/N-DLC films were deposited to analyze and explore the role of N-incorporation on the structure, mechanical properties and tribological behaviors of Si-DLC films and the low friction and wear mechanism of Si/N-DLC films by controlling the flow of N2 precursors, which taken advantage of plane cathode plasma enhanced chemical vapor deposition (PC-PECVD) technology. The results showed that the surface and cross-sectional morphologies of as-deposited Si/N-DLC film were uniform and compact, and the microscopic defects and cracks were not observed. No stratification was observed between the substrate and the transition layer, and between the transition layer and Si/N-DLC film, exhibiting an excellent adhesion. The introduction of N element induced the formation of ring sp2 carbon structure in DLC films, resulting in the increase of sp2-C content in Si-DLC films, in other words, N-incorporation leaded to the graphitization transition of Si-DLC structure, meaning that the structure of Si-DLC films was more orderly. Besides, the reduction of sp3 fraction caused by N-incorporation increased the hardness and elastic modulus of the films. Interestingly, with the enhancement of N content, the toughness of Si-DLC films and the adhesion with the substrate exhibited a trend of first increasing and then decreasing. The incorporation of a appropriate amount of N element (50 sccm) improved significantly the toughness and the adhesion (>20 N). More importantly, N-incorporation effectively reduced the friction coefficient of Si-DLC film and improved the wear resistance. Compared with Si-DLC film, Si/N-DLC films generally showed lower friction coefficient and wear rate, which decreased firstly and the increase with the improvement of N content. Si/N-DLC film deposited with the N2 flow of 75 sccm showed the lowest friction coefficient (0.039 5) and wear rate 1.63×10−7 mm3/(N·m), which were reduced by about 26% and 45% compared with the Si-DLC film (0 sccm), respectively. The friction mechanism was that the formation of graphite-like carbon (GLC) transfer film composed of C, Si and O element, resulting in the transfer of friction interface from GCr15/DLC to the GLC transfer film /DLC. In addition, the decrease of the friction coefficient depended on the graphitization degree and hydrogen content of the friction interface. On the one hand, the sliding interface with high graphitization degree was easy to shear, resulting in low interface friction; On the other hand, there was a repulsive force between hydrogen on the surface of GLC transfer film and hydrogen on the surface of Si/N- DLC film, and it was enhanced with the increase of interface hydrogen content, which promoted the sliding of friction interface and further reduced the friction coefficient of Si/N-DLC film system. The wear behaviors were limited to the film toughness and the ability to resist elastoplastic deformation. The brittle fracture notch formed inside the wear track of Si/N-DLC films with low N-incorporation content, which was attributed to the lower film toughness. It caused large area damage of the transfer film, and aggravated the adhesive wear. In addition, the optimal service range (contact pressure and maximum sliding linear velocity) of Si/N-DLC films with low friction (≤0.05) was determined. The relevant results provided reference for structure and property regulation and engineering application of Si/N-DLC films.

     

/

返回文章
返回