ISSN   1004-0595

CN  62-1224/O4

高级检索
魏永峭, 杨海江, 郭瑞, 刘永平, 董长斌. 混合润滑下变双曲圆弧齿线圆柱齿轮摩擦特性及传动效率分析[J]. 摩擦学学报(中英文), 2024, 44(8): 1−12. doi: 10.16078/j.tribology.2023213
引用本文: 魏永峭, 杨海江, 郭瑞, 刘永平, 董长斌. 混合润滑下变双曲圆弧齿线圆柱齿轮摩擦特性及传动效率分析[J]. 摩擦学学报(中英文), 2024, 44(8): 1−12. doi: 10.16078/j.tribology.2023213
WEI Yongqiao, YANG Haijiang, GUO Rui, LIU Yongping, DONG Changbin. Analysis of Friction Characteristics and Transmission Efficiency of Gear with Variable Hyperbolic Circular-Arc-Tooth-Trace under Mixed Lubrication[J]. Tribology, 2024, 44(8): 1−12. doi: 10.16078/j.tribology.2023213
Citation: WEI Yongqiao, YANG Haijiang, GUO Rui, LIU Yongping, DONG Changbin. Analysis of Friction Characteristics and Transmission Efficiency of Gear with Variable Hyperbolic Circular-Arc-Tooth-Trace under Mixed Lubrication[J]. Tribology, 2024, 44(8): 1−12. doi: 10.16078/j.tribology.2023213

混合润滑下变双曲圆弧齿线圆柱齿轮摩擦特性及传动效率分析

Analysis of Friction Characteristics and Transmission Efficiency of Gear with Variable Hyperbolic Circular-Arc-Tooth-Trace under Mixed Lubrication

  • 摘要: 齿轮在实际运行中由于润滑状态的不同,齿面摩擦系数存在显著差异,从而对齿轮的传动效率产生影响. 变双曲圆弧齿线(VH-CATT)圆柱齿轮通常工作在混合润滑状态下,采用载荷分担理论推导了混合润滑下VH-CATT圆柱齿轮摩擦系数计算公式,建立了混合润滑下VH-CATT圆柱齿轮传动效率计算模型,并通过绘制Stribeck曲线,研究了表面形貌参数、润滑油参数和法向载荷等对混合润滑状态下VH-CATT圆柱齿轮摩擦性能和传动效率的影响规律. 研究结果表明:表面形貌参数的变化会导致混合润滑区扩大,从而使相同速度下的摩擦系数增大;润滑油黏度的增加会导致摩擦系数增大,同时Stribeck曲线向左移动,混合润滑区向边界润滑区扩展;载荷对Stribeck曲线的影响集中体现在混合润滑区与边界润滑区的过渡阶段;随着转速的增加,传动效率逐渐升高并趋于稳定,而在齿轮转速较低时,润滑油黏度和粗糙度对齿轮传动效率有显著影响.

     

    Abstract: In practical applications, gears often exhibit varying lubrication conditions, resulting in significant fluctuations in the friction coefficients of gear pairs. These variations directly affect the transmission efficiency of gears. The present study focuses on variable hyperbolic circular arc toothed tooth (VH-CATT) cylindrical gears, which typically operate under the mixed lubrication conditions. To calculate the friction coefficient of VH-CATT cylindrical gears, the curvature, speed, load, and other pertinent parameters in the contact area were calculated in this paper. Furthermore, by integrating measured roughness data from gear surfaces, the friction coefficient of VH-CATT cylindrical gears under the mixed lubrication conditions was derived using the load sharing theory. Subsequently, a transmission efficiency calculation model for VH-CATT cylindrical gears was established. Through drawing the Stribeck curve, the influence of surface morphology parameters, lubricant parameters, normal load, etc. on the friction coefficient, friction performance and transmission efficiency of VH-CATT cylindrical gears under mixed lubrication were investigated. To further illustrate the interaction of these parameters, consider an example where a VH-CATT gear operating under mixed lubrication experienced a sudden increase in normal load. Without proper lubrication, this increase could lead to rapid wear and a significant increase in friction coefficient, affecting both friction performance and transmission efficiency. However, with an appropriate lubricant, the protective oil film could absorb the increased pressure, reducing wear and maintaining a low friction coefficient. The results showed that the friction coefficient exhibited a pattern of first decreasing and then increasing as the rotational angle increases. Notably, the friction coefficient attained its lowest value at the node. This phenomenon could be attributed to the concurrent presence of sliding and rolling friction during gear meshing. However, in the vicinity of the node, the gears were primarily in a state of pure rolling, resulting in the predominance of rolling friction. Furthermore, the friction coefficient exhibited a decreasing trend as the rotational speed increases. This observation was explained by the fact that the convolution speed of the gear pair augments with an increase in rotational speed. The alteration in surface topography parameters gave rise to an expansion of the mixed lubrication zone, subsequently elevating the friction coefficient at equivalent velocities. Concurrently, a surge in the lubricating oil's viscosity escalated the coefficient of friction, resulting in the Stribeck curve shifting towards the left and the mixed lubrication zone broadening towards the boundary lubrication zone. The load's impact on the Stribeck curve was primarily observed in the transitional phase between the mixed and boundary lubrication zones. As speed increased, transmission efficiency gradually rose towards a state of stability. Conversely, at lower gear speeds, the viscosity and roughness of the lubricating oil exerted a notable influence on gear transmission efficiency. In conclusion, the influence of surface morphology parameters, lubricant properties, and normal load on the friction coefficient, friction performance, and transmission efficiency of VH-CATT cylindrical geared under mixed lubrication was multifaceted and requires careful consideration. By optimizing these parameters, it was possible to significantly enhance gear performance and durability, leading to improved overall system efficiency and reliability.

     

/

返回文章
返回