ISSN   1004-0595

CN  62-1224/O4

高级检索
叶家往, 于爱兵, 秦拓, 王家炜, 齐少春, 赵家震, 汤维冬. 滚珠润滑表面的摩擦学性能及其润滑机理[J]. 摩擦学学报(中英文), 2025, 44(0): 1−10. doi: 10.16078/j.tribology.2023252
引用本文: 叶家往, 于爱兵, 秦拓, 王家炜, 齐少春, 赵家震, 汤维冬. 滚珠润滑表面的摩擦学性能及其润滑机理[J]. 摩擦学学报(中英文), 2025, 44(0): 1−10. doi: 10.16078/j.tribology.2023252
YE Jiawang, YU Aibing, QIN Tuo, WANG Jiawei, QI Shaochun, ZHAO Jiazhen, TANG Weidong. Tribological Properties and Lubrication Mechanisms of Rolling Ball Lubricated Surface[J]. Tribology, 2025, 44(0): 1−10. doi: 10.16078/j.tribology.2023252
Citation: YE Jiawang, YU Aibing, QIN Tuo, WANG Jiawei, QI Shaochun, ZHAO Jiazhen, TANG Weidong. Tribological Properties and Lubrication Mechanisms of Rolling Ball Lubricated Surface[J]. Tribology, 2025, 44(0): 1−10. doi: 10.16078/j.tribology.2023252

滚珠润滑表面的摩擦学性能及其润滑机理

Tribological Properties and Lubrication Mechanisms of Rolling Ball Lubricated Surface

  • 摘要: 为了提高乏油条件下试件表面的摩擦学性能,以凹坑织构表面为基础,提出并制备了1种新的具有滚珠润滑单元的织构表面,即滚珠润滑表面. 采用球盘式摩擦磨损试验对比了3种表面的摩擦学性能,3种表面分别为未织构表面、凹坑织构表面以及滚珠润滑表面. 利用高速摄影机观测了滚珠运动状态和润滑油成膜情况,并分析了滚珠润滑表面的润滑机理. 研究结果表明:与未织构表面相比,凹坑织构表面和滚珠润滑表面的摩擦系数和磨痕截面面积降低,低摩擦系数状态的持续时间延长,其中滚珠润滑表面的摩擦系数和磨痕截面面积最低,低摩擦系数状态的持续时间最长;在未织构和凹坑织构磨痕表面观察到犁沟和材料剥落现象,在滚珠润滑磨痕表面观察到犁沟现象. 滚珠润滑表面通过挤压出油和滚珠滚动带油2种润滑机制将润滑油带入摩擦界面,滚珠润滑单元显著增加了摩擦界面的供油量,提高了凹坑内润滑油的利用率,以少量润滑油获得了良好的织构表面摩擦学性能.

     

    Abstract: A new textured surface with rolling ball lubricated unit, namely the rolling ball lubricated surface was proposed and fabricated based on the dimple textured surfaceto improve the tribological properties of the specimen surfaces under starved lubrication conditions. The fabrication processes of rolling ball lubricated surfaces were as follows. Firstly, the textured dimples were machined on the surfaces of 45 steel with laser machine. The average diameter and depth of the dimples were 597.5 and 832.7 μm, respectively. Then, polyurethane sponges were filled into the dimples and the lubricating oil was dripped into the dimples with a dropper. Then, a rolling ball with a diameter of 500 μm was placed into the dimple. Finally, after the excess lubricating oil on the specimen surface was wiped off, the rolling ball lubricated surface was obtained. Ball-on-disc wear experiments were conducted to compare tribological properties of three types of surfaces: untextured surface, dimple textured surface and rolling ball lubricated surface. Thecross-sectional areas of worn tracks were measured and the worn surfaces were observed. The experimental results showed that among the three types of surfaces, rolling ball lubricated surfaces had the lowest friction coefficients and cross-sectional areas of worn tracks. Compared with dimple textured surfaces, the friction coefficients and cross-sectional areas of worn tracks of rolling ball lubricated surfaces decreased by 61.0% and 84.5%. Ploughing and spalling phenomena could be observed on both the worn tracks of untextured surfaces and dimple textured surfaces, while only ploughing marks could be observed on the worn tracks of rolling ball lubricated surfaces. A high-speed camera was used to observe the formation of lubricating oil film and the rolling ball movement to study the lubrication mechanisms of rolling ball lubricated surfaces. The experimental results showed that the lubrication mechanisms of the rolling ball lubricated surfaces included two ways: squeezing out oil by the counterpart ball and carrying oil by the rolling ball. At the beginning of the tribological experiments, the lubricating oil within the dimples was relatively sufficient. At this moment, the lubricating oil within the dimples could be squeezed out and enter the friction interface when the counterpart balls squeezed the rolling balls. The lubricating oil in the dimples was gradually consumed with the processing of tribological experiments. At this time, the lubricating oil could not be squeezed out again when the counterpart balls squeezed the rolling balls. The remained lubricating oil within the dimples could be carried to the contact areas between the counterpart balls and the rolling balls with the rotation of the rolling balls. The counterpart balls were in contact with the rolling balls attached with lubricating oil, so the counterpart balls were covered with lubricating oil. Lubricating oil was carried to the friction interface by the counterpart balls, and the lubrication oil within the dimples could be further utilized. In addition, the maximum amounts of oil that dimples and rolling ball lubricated units could supply to the friction interface were calculated and compared. The calculation results showed that the maximum amounts of oil that dimples and rolling ball lubricated units could supply to the friction interface were 2.5×106 and 45.6×106 μm3, respectively. Compared with the dimples, the maximum amounts of supplied oil to the friction interface of rolling ball lubricated units increased by 17.24 times. The above research work indicated that rolling ball lubricated units could significantly increase the amount of supplied oil to the friction interface, improve the utilization of lubricating oil within dimples, and obtain good tribological performance of textured surfaces with a small amount of lubricating oil.

     

/

返回文章
返回